From: "Secretary, ACS Division of Chemical Health and Safety" <secretary**At_Symbol_Here**DCHAS.ORG>
Subject: [DCHAS-L] Beware drying nitrate-containing protic ionic liquids
Date: Fri, 6 Dec 2013 07:53:19 -0500
Reply-To: DCHAS-L <DCHAS-L**At_Symbol_Here**MED.CORNELL.EDU>
Message-ID: D2416E70-5D76-44E5-8414-89749C12E874**At_Symbol_Here**

From: The Safety Zone [mailto:donotreply**At_Symbol_Here**]
Sent: Thursday, December 05, 2013 4:24 PM
Subject: [New post] Beware drying nitrate-containing protic ionic liquids

Beware drying nitrate-containing protic ionic liquids
by Jyllian Kemsley
"A batch of the protic ionic liquid pyrrolidinium nitrate exploded while drying it under reduced pressure at 110 =B0C, using a rotary evaporator with an oil bath."

So says a paper in Green Chemistry authored by researchers from KU Leuven and Umicore, both located in Belgium (Green Chem. 2013, DOI: 10.1039/c3gc41328d).

While ionic liquids typically have low vapor pressures and high flash points, that doesn't mean they're hazard-free, as the documented experience indicates. KU Leuven chemistry professor Koen Binnemans and colleagues were investigating a series of pyrrolidium ionic liquids with different coordinating groups, one of which was nitrate. The researchers report:

After stirring at room temperature for 4 hours, the remaining pyrrolidine, water and nitric acid were removed on a rotary evaporator under reduced pressure (16 mbar) at 70 =B0C. Heating of the flask on the rotary evaporator was done by means of a hot silicon oil bath. Not all of the water could be distilled off, and the temperature was increased stepwise to 110 =B0C. Suddenly an explosion occurred. The glass round-bottom flask was scattered and part of the hot silicon oil in the heating bath was blasted by the shock to the walls and ceiling in the neighborhood of the rotary evaporator. At the same time, a cloud of reddish-brown nitrogen dioxide gas was visible. Luckily, nobody was injured and there was only material damage.

The explosion can be attributed to the strong oxidizing properties of concentrated nitric acid under the anhydrous conditions, resulting in a violent oxidative decomposition of the organic compounds. A search of the literature revealed that mixing of nitric acid with secondary amines like pyrrolidine
has been reported to cause violent reactions. Clark described secondary and tertiary amines as hypergolic with nitric acid.

If you need to dry a nitrate-containing protic ionic liquid, they recommend vacuum freeze-drying rather than heating.

This also seems like an opportune time to remind people of what Prudent Practices has to say about nitric acid generally:

Nitric acid is a strong acid, very corrosive, and decomposes to produce nitrogen oxides. The fumes are very irritating, and inhalation may cause pulmonary edema. Nitric acid is also a powerful oxidant and reacts violently, sometimes explosively [with] reducing agents (e.g., organic compounds) with liberation of toxic nitrogen oxides. Contact with organic matter must be avoided. Extreme caution must be taken when cleaning glassware contaminated with organic solvents or material with nitric acid. Toxic fumes of NOx are generated and explosion may occur.

Please remember to separate nitric acid from organics in both storage and waste.

Jyllian Kemsley | December 5, 2013 at 5:23 pm | URL:

Previous post   |  Top of Page   |   Next post

The content of this page reflects the personal opinion(s) of the author(s) only, not the American Chemical Society, ILPI, Safety Emporium, or any other party. Use of any information on this page is at the reader's own risk. Unauthorized reproduction of these materials is prohibited. Send questions/comments about the archive to
The maintenance and hosting of the DCHAS-L archive is provided through the generous support of Safety Emporium.