From: Alan Hall <ahalltoxic**At_Symbol_Here**MSN.COM>
Subject: Re: [DCHAS-L] Vaseline and oxygen
Date: October 19, 2012 11:45:10 AM EDT
Reply-To: DCHAS-L <DCHAS-L**At_Symbol_Here**MED.CORNELL.EDU>
Message-ID: <008f01cdae0f$19263810$4b72a830$**At_Symbol_Here**chemical-safety.com>


Neal et al,
 
However, home  medical oxygen is usuallhy supplied from an O2 concentrator and administered by nasal prongs.  The one I unfortunately had to work with for years could be adjusted from about 1-6 L/minute, and the delivered O2 concentrtion was probably less than 50% (and more likely about 30%).  We were at about 7,400  feet  above MSL, so the lower figure is more likely.  Even when using medical O2 tanks, the regulators also provide about the same L/min flow rates.  However, what's in the taks IS 100%, so if the regulator etc. fails, there is clearly a fire hazard risk (and the risk of rocketing should the whole assembly fail).
 
Alan
 

Date: Fri, 19 Oct 2012 08:33:31 -0700
From: neal**At_Symbol_Here**CHEMICAL-SAFETY.COM
Subject: Re: [DCHAS-L] Vaseline and oxygen
To: DCHAS-L**At_Symbol_Here**MED.CORNELL.EDU

Mary Beth

This is real, but is concentration dependent.  I do not have any patient injury citations, but the following scenario is related to actual fires =96

100% O2 via nasal cannula with petroleum jelly (Vasoline) applied to nostrils will result in an ignition.

 

We have very good documentation of this when a petroleum jelly is exposed to 100% O2 at 1 bar so it is an easy extrapolation to the above scenario.

 

Further, we have good examples of fires when the O2 concentration is elevated and there is an ignition source (cigarette).

 

So, yes this can be a problem

nl

 

 

------------------------------------------------------------------------------------

The information contained in this message is privileged and confidential and protected from disclosure. If the reader of this message is not the intended recipient, or an employee or agent responsible for delivering this message to the intended recipient, you are hereby notified that any dissemination, distribution or copying of this communication is strictly prohibited. If you have received this communication in error, please notify us immediately by replying to the message and deleting it from your computer.

 

ACSafety has a new address:

NEAL LANGERMAN, Ph.D.

ADVANCED CHEMICAL SAFETY, Inc.

PO Box 152329

SAN DIEGO CA 92195

011(619) 990-4908 (phone, 24/7)

www.chemical-safety.com

 

We no longer support FAX.

 

 

From: DCHAS-L Discussion List [mailto:dchas-l**At_Symbol_Here**MED.CORNELL.EDU] On Behalf Of Mary Beth Mulcahy
Sent: Friday, October 19, 2012 7:32 AM
To: DCHAS-L**At_Symbol_Here**MED.CORNELL.EDU
Subject: [DCHAS-L] Vaseline and oxygen

 

Just curious about this and thought some people on this list-serve might have some insightful thought on a topic I stumbled upon (and if I were still a teacher would be a fun test questions to throw at students just to get them thinking).

I had a newborn nephew who was recently on portable oxygen. At some point my sister-in-law said you aren't allowed to have perfume or Vaseline near the oxygen because it can catch on fire. This struck me as odd that she would be cautioned this way since she was using some type of solvent soaked pad to clean the spot where she was going to be putting an adhesive for the oxygen tube to be put on my nephew's face.

I have never thought of Vaseline being particularly hazardous, so of course I immediate began to consult with Dr. Google. One of the warnings I found online was:

"Never use oil-based face or hair creams, a hair dryer or an
electric razor. It is possible in certain conditions that the combination
of oxygen, oil-based toiletries and a spark from an electrical
appliance, such as an electric blanket, hair dryer, electric razor or
heating pad, could ignite and cause burns. Never use oil based hair
lubricants, face and hand lotions, petroleum jelly products, or
aerosol sprays. Always use water-based cosmetics or creams." (http://www.firsttoserve.com/files/cylinder_oxy.pdf)

I also thought found the article titled "Dispelling the Petroleum Jelly Myth" (someone posted the article in a forum found here http://respiratorytherapydriven.blogspot.com/2007/11/vaseline-and-oxygen-flame-on.html).

Then I decided to call a real medical doctor (my sister) to ask about it. She said that she doubted there was any hard evidence out there that this is a hazard, but that somewhere, someone had an accident, hospital got sued, and now it is a "risk" that is being mitigated in hospitals (including hers).

Anyone out there done experiments to try and catch Vaseline on fire? Anyone know the case where Vaseline was identified as a root cause in an accident involving a patient being burned?

Beyond a intellectual curiosity on the topic, it makes me wonder how we promote safety and what we ask people to focus on. Is is scientifically based (does it need to be)? Is it a knee jerk reaction? Is it a systematic approach? The cartoon below portrays how some people I have spoken to look at OSHA regulations. The problem is that if this is the view a person has of safety regulations/standards, I believe he or she will lose faith in the regulations, potentially not following them and thus losing the benefit they can provide. (Disclaimer: I put this cartoon here not because it is how I view OSHA regulations, but because i think it can help spur conversation.)


Mary Beth

Previous post   |  Top of Page   |   Next post



The content of this page reflects the personal opinion(s) of the author(s) only, not the American Chemical Society, ILPI, Safety Emporium, or any other party. Use of any information on this page is at the reader's own risk. Unauthorized reproduction of these materials is prohibited. Send questions/comments about the archive to secretary@dchas.org.
The maintenance and hosting of the DCHAS-L archive is provided through the generous support of Safety Emporium.